Product ID:ALL TEMP EPOXY UNDERCOATER PART A, 4171
MSDS Date:11/02/1988
FSC:8040
NIIN:00N024194
Kit Part:Y
MSDS Number: BMFPM

PETTIT PAINT CO INC

36 PINE ST
BOROUGH OF ROCKAWAY, NJ 07866
US

Emergency Phone: 201-625-3100

Info Phone: 201-625-3100

Cage: 11111

KOP-COAT INC

ROCKAWAY, NJ 07866 US

Telephone: 201-625-3100; 800-221-4466

Cage: 11111

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (1

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 10%

BARIUM SULFATE

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

(ORAL,RAT)13.3 ML/KG

CAS: 64742-94-5

RTECS: WF3100000

Fraction By Weight: 5%

(ORAL,RAT)>9500 MG/KG

CAS: 1317-80-2

RTECS: XR2275000

Fraction By Weight: 20%

OSHA PEL 10 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

METHYL ISOBUTYL KETONE (HEXONE) (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM/75 STEL; 9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BREATHING VAPOR WILL BE IRRITATING TO
NOSE AND THROAT. MAY CAUSE NAUSEA AND VOMITING. CONTACT WITH SKIN
OR EYES MAY BE IRRITATING. MAY BE ABSORBED THROUGH SKIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:IF OVERCOME BY EXPOSURE, REMOVE TO FRESH AIR.
ADMINISTER O*2/ARTF RESP AS NEEDED. GET MED ATTN @ ONCE. SKIN: WASH
AFFECTED AREA WITH WATER. EYES: FLUSH WITH WATER FOR AT LEAST 15
MIN. GET MED CA RE IF DISCOMFORT PERSISTS. INGEST: DO NOT INDUCE
VOMIT. GET IMMED MED HELP.

Flash Point Method:CC
Flash Point:110F,43C
Lower Limits:1%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.

Spill Release Procedures:SMALL SPILLS SHOULD BE FLUSHED WITH LARGE QTY
OF WATER. LARGER SPILLS SHOULD BE COLLECTED FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT AND OPEN FLAME.
KEEP CONTAINER CLOSED.
Other Precautions:NONE.

Respiratory Protection:NIOSH/MSHA APPROVED HYDROCARBON VAPOR CANISTER
OR NIOSH/MSHA APPROVED SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED PLACES IF OCCUPATIONAL EXPOSURE LIMITS ARE
EXCEEDED.
Ventilation:EXHAUST AT OVER 60 FPM.
Protective Gloves:RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:CLOTHING TO KEEP COVERED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

HCC:F4
Boiling Pt:B.P. Text:313F,156C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:30

Stability Indicator/Materials to Avoid:YES
AVOID CONTAMINATION WITH STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING MAY
PRODUCE CARBON DIOXIDE AND/OR CARBON MONOXIDE.

Waste Disposal Methods:INCINERATE IN FURNACE WHEN PERMITTED UNDER
APPROPRIATE FEDERAL, STATE, AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.